Organic acids in bread-making affecting gluten structure and digestibility.

Although wheat gluten has remarkable technological properties, it can induce adverse immune reactions in susceptible individuals, such as wheat allergy and celiac disease. Technological processing and some additives on bread formulation can modify gluten physicochemical structure, but the knowledge about the impacts on the digestibility and immunogenicity of gluten is limited. The present study aimed to study the effect of adding organic acids (acetic or ascorbic) on dough rheological properties and bread technological characteristics. In addition, breads were subjected to in vitro digestion and the digesta were analyzed by confocal microscopy, SDS-PAGE and ELISA immunoassay. Acetic acid resulted in a decrease in dough development time up to 44 % and a reduction in stability up to 20 %. Ascorbic acid, present in vinegar, on the other hand, increased elastic modulus (G') and resistance to extension of dough. After the in vitro digestion, SDS-PAGE indicated that protein degradation started in the gastric phase, with the generation of low molecular weight peptides. Accordingly, ELISA immunoassay suggested a great reduction in immunogenic gliadin content from oral to gastric phase. At the end of the intestinal phase, samples with ascorbic acid did not differ from the control, while vinegar addition indicated a reduction in gluten immunogenicity with a reduction of about 44 % in immunogenic gliadin content compared to the control. Results show a window of opportunity in the modulation of wheat bread formulation with reduced allergenicity, while maintaining the technofunctional properties.

Effect of supercritical CO2 fractionation of Tahiti lemon (Citrus latifolia Tanaka) essential oil on its antifungal activity against predominant molds from pan bread.

This study aimed to verify the in vitro antifungal activity of Tahiti lemon essential oil (LEO) and its fractions, obtained by supercritical CO2 fractionation, against Penicillium sumatrense and Aspergillus niger isolated from pan bread. For this, LEO was solubilized (20 MPa and 40 °C) and fractionated (10 MPa and 40 °C) in supercritical CO2, resulting in soluble (SF) and precipitated (PF) fractions. LEO, SF and PF volatile compounds were identified by gas chromatography coupled to mass spectrometry (GC-MS) and semiquantified by gas chromatography with a flame ionization detector (GC-FID). To evaluate the in vitro antifungal activity of the essential oils (LEO, SF and PF), the minimal inhibitory and fungicidal concentrations (MIC and MFC, respectively) were determined using the 96-well plate methodology. For this, pan breads ware prepared with no preservatives and stored for seven days at 25 °C, and their pH, water activity and moisture contents were determined. Then, two predominant species (Penicillium sumatrense and Aspergillus niger) were isolated from pan breads, characterized according to their morphological and molecular characteristics, and were used in the antifungal activity studies. LEO and its fractions presented monoterpenes, sesquiterpenes and their oxygenated derivatives in their composition. Specifically, limonene was the major component identified in the essential oils. SF showed greater antifungal potential than PF and LEO, showing that supercritical CO2 fractionation could improve the antifungal efficiency of LEO. The results suggest that LEO and its fractions may contribute to the inhibition of Aspergillus niger and Penicillium sumatrense growth in pan breads.

Chickpea Aquafaba-Based Emulsions as a Fat Replacer in Pound Cake: Impact on Cake Properties and Sensory Analysis.

This study evaluates the use of chickpea aquafaba (CA)-based emulsions as a potential substitute for palm oil (PO), using pound cake as a case study. The CA was characterized in terms of pH (6.38 ± 0.01), density (1.02 g mL-1 ± 0.01), color, total soluble solids (6.3 ± 0.2 °Bx), total solids (5.7 ± 0.2%), thermal properties through DSC, and apparent viscosity (2.5 cPa·s-1 ± 0.02 at 300 s-1). Emulsions containing 35, 30, and 25% of CA were produced and applied to cake formulation C1, C2, and C3, respectively. The cake batter was evaluated in terms of apparent density (0.87-1.04 g1 cm-3), rheology, and pH (6.6-6.8). The cakes were evaluated for specific volume, baking loss (8.9-9.5%), color, and symmetry index on day 1, and firmness, water activity (aw), and moisture content (%), after 14 days of storage. The cakes produced with the emulsions were found to have slightly higher specific volume (2.3 cm3 g-1) when compared to the control (C4) produced with PO (2.2 cm3 g-1). The moisture and aw decreased and firmness increased during storage. In terms of formulation (i.e., day 1 for C1, C2, C3, and C4), there was no significant difference for moisture. As for aw, the C4 (0.90) was significantly different from the cakes produced with emulsions (0.91-0.92). The results from the sensory evaluation, carried out with 120 panelists, showed no statistically significant difference between C3 and C4 for the attributes of aroma, color, texture, flavor, and overall impression. Based on our results, it appears that the CA-based emulsions have the potential to replace PO in pound-cake recipes, reducing total and saturated fat.